It was very shaky. Had the battery reset had no impact on the problems I would say it's a mechanical matter, but it seems clear its a computer or electrical issue. The dealer cleaned the throttle body to remedy the failure, but the failure recurred approximately one year later. They swapped it with a 2006 five hundred motor. When this happens the reverse lights come on even when in drive. My car started chugging and running rough so I figured it was another coil. Who buys a car to keep dumping cash into it & burdening people for rides?????? happened last month i chnaged throttle body and had had pcm updated still going limp and wrench light still comes. Now it cuts off while driving and reverse light on while dash is out, See More 2005 Ford Five Hundred Questions, Why is my rear passenger side tire sitting wrong after I changed my breaks, what causes fuel pressure sensor to fail repeated, why are my electronics in my 2006 ford five hundred diming and going bright again when i press the throttle, Battery Cable Battery Terminal End Service, Powertrain Control System Diagnosis & Testing. Thanks for the update. Now it cuts off while driving and reverse light on while dash is out 0 replies Report Answer Get it fixed today at a shop near you The oil has been changed, air filter, radiator fluid, battery good. . updated 05/23/11. I am typically not one to complain, but I feel very strongly about the safety of this vehicle, especially since I have a 3yr old daughter. CarComplaints.com Notes: The 2002-2005 Explorer has a very. About 10 minutes later after a full stop the vehicle had another acceleration while foot on brake and the vehicle stalled out. I really feel a class action suit or recall is needed. Pull over, read owner's manual. After researching the internet, I have come to find that this is a common occurrence with Ford and an announced recall should be implemented immediately. Is there anyone else that has had this problem. the car could stall at anytime while driving putting myself and my family at risk, I don't think much of this automobile company for not standing behind there product, I will never recommend a Ford vehicle to friends,family or even my worst enemy never never again!!!!. Park the truck nose down. It's in perfect condition except for one thing. Dashboard lit up and immediately lost all power to car. However, none of these parts are available due to being on backorder. While driving all controls are lost, e.g. 2005 Ford F150 Starter Fuse LocationFord F-250 / F-350 / F-450 / F-550 this is on a 2007 Ford 500, low miles. I could barely get it to go any faster than 25 MPH. Time will pass and it will eventually come back on, after a couple weeks. I ran a scan tool on it figuring maybe the fuel filter or ground wire maybe but nothing showed up that would cause the car to quit running like this. Took it to auto parts store and got a P2104 code for Accelerator Pedal Position Sensor. Can seem to run fine, be in the middle of an intersection and the car shut off and wouldnt restar good thing I can drive and knew what to do or I would have crashed numerous times. We have replaced the fuel pump and spark plugs. Without touching the gas my 2005 Ford Five Hundred lunged at the building as if the throttle was stuck wide open! Since I have been reading up on the issue I noticed that there was a letter sent out to owners of my model which I did not receive. There are countless others who have filed complaints and concerns regarding this very issue. Instrument cluster not working. which is now bankrupt from what I have been told. GAUGE CLUSTER ISSUES SOLVED HERE! - Ford Power Stroke Nation I was in a lot of traffic, 2 lanes and I was in the left lane. If mine wasnt on while starting, the truck would idlr high and feel like trans was slipping while depressing gas made the truck nearly die. What if I was at a gas station when this happened when their happened to be some petrol-vapor present. This is dangerous and should be an electrical recall. The contact stated that while driving 70 mph, the wrench warning indicator illuminated as the vehicle stalled. Today, while driving it died. It often happens on the highway, but also on residential streets and at all speeds. 2006 Ford Mustang Shuts Off While Driving? Have replaced all parts suggested by codes. Post It turns out it is a faulty instrument cluster, just like the TSB mentioned. When you purchase through links on our site, we may earn an affiliate commission, which supports our community. Now saying it's the pcm shutting the car off. Shutting off while driving! I was in heavy traffic and the car just stalled out on me while sitting at a light. install it and then test the new PCM. Still no fix. Have run code in my car and only code is p0193 fuel rail pressure sensor. I know your car is a 2007 , but is it possible it was older stock when registered and is affected with this ? Both times it cranked back up with no issues. No problems with it until the next day when the check engine light came on. There are countless reviews on this problem, it should not be left up to the consumer to take on such a significant expense. Thank God it was all down hill. FORD FIVE HUNDRED OWNER'S MANUAL Pdf Download | ManualsLib Waited 2 min. The next day I took it to the Ford dealership and the wrench light and check engine came on. While driving 60 mph, the vehicle failed to accelerate and the power train wrench icon illuminated. I had to carpool for about a week, and the warranty did not cover the problem. The vehicle was taken to the dealer where the contact was awaiting a full diagnosis of the failure. Would not start, had towed to mechanic. They said it was bad ignition coil packs. Would start up but could not go over 10 miles per hour. While driving about two weeks ago, the little wrench light came on and I lost power. Happened a third time at the store. Pulled over and shut car off and restarted it again a few minutes later and everything was fine. 1)The car loses power and shuts down temporarily while driving. When I Start It It Sputters. To restart, must shut car off, key out and it will restart. It began with the 12 volt not working. The vehicle had random acceleration while at full stopped. Had to have it towed. Additionally, when I tried to use my emergency lights, they would also go off whenever the panel went out. The vehicle would then stall once the message was displayed and would not restart. Do Not Sell or Share My Personal Information, 2006 F150 5.4 Sputtering - New thread CONDENSED, https://www.morepowertuning.com/how-to-idle-relearn. If the key is not removed, it will not restart. statistics and reliability analysis of Ford Five Hundred based on all problems reported for the Five Hundred. In my opinion, the computer caused the problem due to a very deficient manufacturing of it. Code is p0191, replaced fuel pump and inertia switch as suggested in tsb. The manufacturer was not notified of the failure. No lights and not running rough. The crankshaft position sensor's role is monitoring the engine's many moving parts including the crankshaft, engine valves, and pistons. Morning after I installed pump, started & shut off again. There are other things to be aware of that could explain the P2285 (Low ICP pressure) code. Why can't ford be held acountable for thjese and fix them at no charge. Signal lights melted and quit working. The contact owns a 2005 Ford Five Hundred. I had my Ford 500 3mos, at first all dash board lights would go outand maybe come back on the same day. [DROF_3380] 02 Ford Excursion Fuse Diagram Fuse Diagram - OSSIE. 2005 Ford Five Hundred Review - NewCarTestDrive The vehicle was taken to a local mechanic who lubricated a component (the contact was unsure of what component) but the failure continued. The failure mileage was 75,000 and the current mileage was 134,000. . This could be a very serious situation if someone is within 15ft when the car goes out of control all by itself and the driver is not ready. Well, I moved houses on the other side of town and had to move it and could not afford a tow so I drove it for about a mile or so and it shut off once at the red light when I had to sit and wait but when it shuts off it will start back up. Also please check out the This car has had so many issues, never again will I buy a FORD!! Towed it to the dealer and the dealer spent over 6 hours to come to the conclusion that throttle body needed to be cleaned and pcm reprogrammed/updated. I think corrective action should be taken towards a resolution. I again did the battery disconnect last night, and the car is operating normal today, but I'm sure it will recur shortly. Pulled over, turned the ignition off and back on and it was fine. back to engine Complaints 2K Crash Tests 3 Recalls 5. Yesterday the check engine light came back, and the car was running poorly (creeping when first off brakes, not up shifting), when the dash was operable it showed alternating check engine/check transmission warnings, and vehicle was surging/lagging noticeably at highway speeds. I always have to be extra careful. truck runs fine. I had no warning, no lights had been coming on. On a trip south on an interstate, my car overheated. While driving one day, my cluster panel went dark. Here is the fix, ford has to fuel pumps, under the rear seat there two openings, driver side is called a left pump, not available at any parts store, dealer or salvage. I then pull over wait for 10 seconds to 2 min and it starts back up. One restarted it returned to normal but the wrench icon light was on the dash. I have a 2007 Ford Five Hundred with 21K miles. Time will pass and it will eventually come back on, after a couple weeks. It is a very scary situation and can happen multiple times a day. And I dont know what to do about this problem. Happens running driving and sitting still. CK Engine light came on SOLID this time and as I started to pull off the highway onto the shoulder, once again the engine died. Ask your Ford dealer. The fail safe mode warning light started to illuminate. The vehicle was not repaired. Once stalled out the computer displayed the following error "fail safe engine". Tl the contact owns a 2005 Ford Five Hundred. JavaScript is disabled. . It Now Won't Even Start A Little, The Warning Says Low Oil Pressure. No lights came on and was able to drive. If this is happening to Explorers, Freestyles, Mustangs and many other makes and models maybe the throttle body assembly was made by the same mfg. I see someone already pointed out no recall on this problem. I live in spokane washington, but I had to have the battery replaced once while I was on vacation in montana. This has been happening every week or so for nearly a year, and no one can tell us what's wrong. My mechanic called the dealership expecting Ford had a recall or would do something to help since it's clearly a problem with this particular year. This happens frequently almost daily in the summer. I will never buy another Ford vehicle ever again!!!!!! Service Engine light then came on and so I got it started again and took it immediately to the nearest auto shop. . Me and my seven year old daughter was in the car. The failure mileage was 126,000. They could not get any codes out of it so then the guessing game started. Everyone basically stating the dealer gives them the run around. The vehicle that I have is a 2005 Ford F-150 4x4 with a 5.4 litre engine. The vehicle was totaled by the insurance company. You cant steer, you cant brake!!! I was driving on freeway to pick my child from daycare when all the sudden the car stalled out. Continued to drive and the instrument cluster began working a few moments later. In this case, it's usually fuel. I can't keep buying and replacing coils on this thing since it's not paid off and in my bankruptcy I can't trade it in either. F550 with 4500 miles shuts off while driving | The Diesel Stop But the alternate is putting our 14.2 at idle.when this issue happens every accessory shuts down except headlights and the engine. Ford Focus Shuts Down While Driving (Common Causes) The failure mileage was 60,000 and the current mileage was 80,000. HELP. I own a 2005 Ford Five Hundred there was a recall in 2012 on the throttle body, a Ford dealer supposably cleaned the throttle body, well now its not driveable. A service station diagnosed the problem and found an electrical short in a computer module which controls the radiator fan. I cannot believe they knew about this issue and moved on. Bought car used, 117,551 miles 8/08/18. 6.0L Power Stroke Diesel - 6.0 randomly shuts off - 04 with 170k miles. It doesn't matter if I'm driving fast on the freeway or slowing down to a stop. I had no breaks or steering anything. The failure and current mileage was 94,000. So, OPTION B.spend $200 for the used cable, let the Ford tech. This car is still under warranty and had all its 5K maintenance serviced from the FORD workshop!!! Last week I was driving down my street and the engine stalled. all problems of the 2006 Ford Five Hundred statistics and reliability analysis of Ford Five Hundred based on all problems reported for the Five Hundred. Seemed just fine. There is something mechanically wrong with this car. I have owned my 2006 Ford 500 for 5 yrs and have had and issue for the last 2 yrs. I then replaced a coil pack. All the alarms went off and the check engine light came on before the power failed. Still occurs. When stopped at a light for instance the idle speed becomes low and sometimes stalls. The underside of the mirror had caught fire and started burning for a bit before the fuse finally blew. Anyone know of recalls to this problem? Last time this occurred car required towing to local Ford dealer. Looking forward to the class action to recover the cost of repairs. the car could stall at anytime while driving putting myself and my family at risk, I don't think much of this automobile company for not standing behind there product, I will never recommend a Ford vehicle to friends,family or even my worst enemy never never again!!!!. I was stopped at an intersection. I Have A 2003 Ford Explorer Sport Trac Xls. The vehicle was taken to a independent mechanic for diagnosis. Back of me car did same thing. While driving various speeds, the vehicle suddenly accelerated independently and there was a sudden increase of engine rpms. Just bought a used Escape in August, everything checked out ok. Ford Taurus, Five Hundred, Sable, MKS, Montego 08+, Ford Crown Vic, Mercury Marauder, Grand Marquis. After stopping the car, I waited a few seconds and restarted it. by racingrush Wed Nov 03, 2010 3:59 am, Post I was able to get stopped, put car in park to prevent rolling backwards, turned the car off and restarted. Used a different key next day, drove to work,home & out to run errands. See The contact owns a 2006 Ford Five Hundred. Without much confidence, they returned the car to me and said they could not replicate the problem. 2005 ford 500 shuts off while driving I have a busted motor mount and transmission mount on a 2005 Ford Five Hundred just as of yesterday here in Memphis it has started to warm up so I had my a/c on yesterday and when in operation while at slow speeds or at stop light the car will idle rough and start shutting on and off for about a millisecond. turn it off the it restarts everytime. For a better experience, please enable JavaScript in your browser before proceeding. The repair of the whole cluster panel is not cheap. On the way home from the movies late one evening my Escape just cut out on the expressway. this has happened to many Ford Five Hundred owners! Then instrument panel speedometer goes black, if you got the dash it comes back on the battery got completely drained bought a new one. 2005 Ford Explorer Engine Stalls/Shuts Off While Driving Wrench indicator light came on and car began to spotter and surge. When Im the vehicle and the temperature reaches middle temp ,the car starts to beep and all the dashboard lights go completely out and the head lights and tail lights be blinking as if they are about to go off . It should be a recall major safety violation. 05 500 Limited, AWD, CVT Amp and 2, 12 inch boomers in the trunk. Only had the car for five months driving doen the street the check engine light came out car stopped in the middle of the street with my children in it and wouldn't start up. Every time, the car comes to stop or dies on me. It is now parked there and when I start it the ECM light comes on. The car was driven from Florida to Philadelphia with no problems and it had its regular inspections. Marcus, the service manager informed me a new wiring harness was now needed since the original one was melted by the PCM shorting out. After reading these comments, I fear driving it, if it starts. FORD Motor Company should take this problem into account and call this model cars for recall. All site content Copyright 2004-var year=new Date(); year=year.getYear(); if (year<1900) year+=1900; document.write(year); FordTaurus.net We are in no way affiliated with Ford Motor Company. On day 6 I accelerated to 50mph and the dash lit up like a christmas tree and just stalled. The approximate failure mileage was 75,000. Prior to replacing the Harmonic Balancer at 50K (Approximately $500.00) the vehicle had behaved the same way, randomly turning off while driving. Mechanic suggested I try putting claim in with insurance company since it involved computer burn but they said mechanical problem was the cause so no coverage. Kw. I have been reading a lot on this car and its problems people have come into and wonder why no recall has been issued. Once the vehicle was restarted, it began to jerk when accelerated. theft light killing car randomly - Ford Truck Enthusiasts Forums